Product ID:E-6100 NON-SLUMP CLEAR (NON-FLAMMABLE), 371000415
MSDS Date:01/06/1997
FSC:6850
NIIN:00N092760
Status Code:A
MSDS Number: CJTZV

Emergency Phone: 800-535-5053

Info Phone: 544-484-9621

Cage: 08AW5

Telephone: 206-622-6034

Cage: 0HLN0

13 @ 68.

CAS: 127-18-4

RTECS: KX3850000

OSHA PEL see Table Z-2

ACGIH TLV: 170 MG/M3;25 PPM

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL HLTH RISKS & SYMPS OF EXPOS:
DIZZ MAY OCCUR AT 200 PPM; PROGRESSIVELY HIGHER LEVELS CAN CAUSE
IRRIT OF RESP TRACT, DRUNKENESS, NAUS, INCOORD, UNCONSCIOUSNESS &
EVEN ASPHY IN CONFINED POORLY VENT AREAS. EXPOS CAN CAUSE CNS DMG.
SKIN &EYE CNTCT HLTH RISKS & SYMPS OF EXPOS: EYES: PROD IN EYES CAN
RSLT IN DISCOMFORT. PAIN & IRRIT. VAPS MAY IRRIT EYES AT ABOUT 100
PPM. SKIN: IRRIT CAN DEVELOP FOL LOWING RPTD &/PRLNG CNTCT & MAY
CAUSE DRYING/FLAKING OF SKIN. SKIN ABSORPTION HLTH RISKS & SYMPS OF
EXPOS: SINGLE PRLNG EXPOS IS NOT LIKELY TO RSLT IN MATL BEING
ABSORBED THRU SKIN ABSORPTION IN RABBI TS IS >10,000 MG/KG. (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:TETRACHLOROETHYLENE: IARC MONOGRAPHS
VOL. 63, PG 159: 1995: GROUP 2A. NTP 8TH ANNUAL REPORT ON
CARCINOGENS; 1998. REASONABLY ANTICIPATED TO BE HUMAN CARCINOGEN.
ANIMAL:LIVER.
Effects of Overexposure:HLTH HAZ: INGEST HLTH RISKS & SYMPS OF EXPOS:
SINGLE DOSE ORAL TOX IS LOW. INGEST MAY RSLT IN IRRIT OF MOUTH & GI
TRACT ALONG W/OTHER EFTS AS LISTED ABOVE FOR INHAL, VOMIT &
SUBSEQUENT ASPIR INTO LUNG S MAY LEAD TO INJURY OF OTHER BODY SYS.
HLTH HAZ (ACUTE & CHRONIC): TETRACHLOROETHYLENE HAS BEEN SHOWN TO
INCR RATE OF SPONTANEOUSLY OCCURING MALIGNANT TUMORS IN CERTAIN LAB
RATS & MICE. OTHER LONG TE RM: INHAL STUDIES IN RATS FAILED TO SHOW
TUMORIGENIC RESPONSE. EPIDEMIOLOGY STUDIES ARE LIMITED & HAVE NOT
ESTABLISHED ASSOC BETWEEN TETRACHLOROETHYLENE EXPOS & CANCER. DID
NOT CAUSE (SUPDAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN, AND LUNG
CONDITIONS.

First Aid:EYES: FLUSH W/H*2O FOR AT LEAST 15 MIN. SEEK MED CARE IF
IRRIT PERSISTS/DEVELOPS. SKIN: WIPE FROM SKIN & WASH W/SOAP & H*2O.
IF IRRIT DEVELOPS SEEK MED ATTN. INHAL: REMOVE TO FRESH AIR. IF
BRTHG IS DF CLT, GIVE OXYGEN. GIVE ARTF RESUSCITATION IF NOT
BRTHNG. INGEST: DO NOT INDUCE VOMIT. CALL A MD. GIVE 1 OR 2
GLASSES OF H*2O. NOTES TO MD: BECAUSE RAPID ABSORPTION MAY OCCUR
THRU LUNGS IF ASPIRATED & CAUSE SYSTEMIC EFTS, DECISION OF WHETHER
TO INDUCE VOMIT/NOT SHOULD BE MADE BY MD. IF LAVAGE IS PERFORMED,
SUGGEST ENDOTRACHEAL &/ESOPHAGAL CONTROL DANGER FROM LUNG
ASPIRATION MUST BE WEIGHED AGAINS T TOX (SUPDAT)

Flash Point:NONE
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . COOL FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:PRODUCT IS NON-FLAMM & NON-EXPLOSIVE
UNDER NORMAL CONDITIONS OF USE. AT HIGH TEMP, PRODUCT DECOMPOSES TO
GIVE OFF HYDROCHLORIC ACID AS GAS PLUS OTHER TOXIC & IRRITATING
VAPORS SUCH AS PHOSGENE & CHLOR INE. IF STORAGE CONTAINERS ARE
EXPOSED TO EXCESSIVE HEAT, OVER-PRESSURIZATION CAN RESULT IN
CONTAINER RUPTURE.

Spill Release Procedures:SMALL LEAKS: WIPE UP, OR SOAK UP IMMEDIATELY
WITH INERT MATERIAL. REMOVE TO OUTDOORS. LARGE SPILLS: EVACUATE
AREA; CONTAIN LIQUID; TRANSFER TO CLOSED METAL CONTAINERS; KEEP OUT
OF WATER SUPPLY.

Handling and Storage Precautions:IN LRG QTIES, LETHAL CONCS MAY EXIST
IN AREAS W/POOR VENT. DO NOT USE IN POORLY VENT/CONFINED SPACES
W/OUT PROPER RESP PROT, VAPS WILL COLLECT IN LOW PLACES SUCH AS
PITS, STORAGE TANKS & OTHER CONFINE D SPACES. DO NOT ENTER THESE
AREAS UNLESS SPECIAL BRTHG APPARATUS IS USED & OBSERVER IS PRESENT.

Respiratory Protection:IF VENTILATION IS INADEQUATE TO MAINTAIN
ATMOSPHERIC LEVELS BELOW THE TLV WEAR NIOSH APPROVED AIR PURIFYING
ORGANIC CARTRIDGE RESPIRATOR. FOR EMERGENCY AND OVER EXPOSURE, USE
AN NIOSH APPROVED POSITIV E PRESSURE SELF-CONTAINED BREATHING
APPRATUS. IN CONFINED OR POORLY VENTILATED AREAS, USE AN APPROVED
POSITIVE PRESSURE SELF-CONTAINED BREATHING APPARATUS.
Ventilation:ADEQUATE VENTILATION SHOULD BE PROVIDED TO KEEP VAPOR
CONCENTRATIONS BELOW ACCEPTABLE EXPOSURE GUIDELINES. USE ONLY WITH
ADEQUATE VENTILATION.
Protective Gloves:NEOPRENE-LATEX GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH & DELUGE SHWR MTG ANSI DESIGN
CRITERIA . AS NEC TO PREVENT SKIN CNTCT. SELECTION OF SPECIFIC
ITEMS SUCH AS GLOVES, BOOTS, APRON/FULL BODY SUIT WILL DEPEND ON
OPERATION, (OTHER INFO)
Work Hygienic Practices:DO NOT ALLOW EYE OR SKIN CONTACT. AVOID
BREATHING VAPORS. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING
OR DRINKING.
Supplemental Safety and Health
HLTH HAZ: BIRTH DEFECTS IN ANIMALS. BIRTH DEFECTS UNLIKELY. PRLNG EXPOS
ABOVE OSHA PERMISSIBLE LIMITS MAY RSLT IN LIVER & KIDNEY DMG. FIRST
AID PROC: WHEN CONSIDERING EMPTYING STOMACH. DO NOT ADMINIST ER
SYMPATHOMIMETIC DRUGH UNLESS ABSOLUTELY NECESSARY. NO SPECIFIC
ANTIDOTE. SUPPORTIVE CARE. (OTHER INFO)

Boiling Pt:>121.1C, 250.F
Vapor Density:HVR/AIR
Spec Gravity:1.32 (H*2O = 1)
VOC Grams/Liter:7.05
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:VISCOUS LIQUID WITH ETHER-LIKE ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND OXIDIZING MATERIALS. AVOID MIXING WITH CAUSTIC SODA OR
POTASH.
Stability Condition to Avoid:AVOID EXTREME HEAT. FLAME OR SPARKS.
Hazardous Decomposition Products:TOXIC/IRRITATING GASES AND FUMES.
HYDROGEN CHLORIDE, CO*2, SIMPLE HYDOCARBONS, PHOSGENE, AND
CHLORINE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:RECLAIM OR INCINERATE THE NON-HARDENED PRODUCT.
MATERIAL RESULTING FROM CLEAN UP OPERATION MAY BE HAZARDOUS WASTE
AND THEREFORE SUBJECT TO SPECIFIC REGULATIONS. DISPOSE OF IN
ACCORDANCE WITH LOCAL, ST ATE AND FEDERAL REGULATIONS AT TIME OF
DISPOSAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:DOT CLASS: SMALL PKG. CONSUMER COMMODITY ORM-D;
1 GAL & LARGER-TETRACHLOROETHYLENE MIXTURE, 6.1, UN 1997, PG III.

SARA Title III Information:TETRACHLOROETHYLENE IS TOXIC CHEMICAL
SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III
AND OF 40 CFR 372.
State Regulatory Information:PROPOSITION 65 STATEMENT: THIS PRODUCT
CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER.